快乐赛车

[1]任 欢,寇晓适,马 伦,等.基于氮化铝陶瓷添加的高导热纳米油变压器挂网应用试验研究[J].高压电器,2020,56(02):93-100,107.[doi:10.13296/j.1001-1609.hva.2020.02.014 ]
 REN Huan,KOU Xiaokuo,MA Lun,et al.Experimental Study on Application of the Transformer with High-thermal-conductivity Oil Added by Nano-AlN Ceramic Particles[J].High Voltage Apparatus,2020,56(02):93-100,107.[doi:10.13296/j.1001-1609.hva.2020.02.014 ]
点击复制

基于氮化铝陶瓷添加的高导热纳米油变压器挂网应用试验研究()
分享到:

《高压电器》[ISSN:1001-1609/CN:61-11271/TM]

卷:
第56卷
期数:
2020年02期
页码:
93-100,107
栏目:
研究与分析
出版日期:
2020-02-14

文章信息/Info

Title:
Experimental Study on Application of the Transformer with High-thermal-conductivity Oil Added by Nano-AlN Ceramic Particles
作者:
任 欢1 寇晓适1 马 伦1 赵 磊1 周远翔2 王 琪2
(1. 国网河南省电力公司电力科学研究院, 郑州 450052; 2. 清华大学电力系统及发电设备控制和仿真国家重点实验室, 北京 100084)
Author(s):
REN Huan1 KOU Xiaokuo1 MA Lun1 ZHAO Lei1 ZHOU Yuanxiang2 WANG Qi2
(1. State Grid Henan Electric Power Research Institute, Zhengzhou 450052, China; 2. State Key Laboratory of Power System and Generation Equipment Control and Simulation of Tsinghua University, Beijing 100084, China)
关键词:
氮化铝 纳米粒子 变压器 油热导率 温升
Keywords:
AlN nano particle transformer oil thermal conductivity temperature rise
DOI:
摘要:
通过在变压器油中添加热导率高的氮化铝(AlN)陶瓷纳米颗粒,可以提高基础油的热导率;但随着混合油的热导率增大,其电气性能有所下降。文中选取的添加浓度,在满足设备电气性能的同时,也使混合油的导热性能大为提升。文中提出了纳米油变压器实际应用方案,通过试验研究了纳米油变压器自然负载、低负载运行及过负载运行工况等实际挂网运行性能,对比研究了纳米粒子的添加对变压器稳态和短时温升提升效果的差异,研究发现氮化铝纳米陶瓷粒子的添加能够加强变压器内部热量的传导,提高变压器的散热效率,但在较低的负荷工况下稳态温升降低幅度小于变压器高负载工况下短时温升的降低幅度。
Abstract:
Adding nano-AlN ceramic particles with high thermal conductivity into basic insulating oil of transformer can improve the oil’s thermal conductivity, however, the electrical performance of the transformer decreases with the thermal conductivity. This research selected proper additive concentration to significantly increase the thermal conductivity of the oil without reducing the electrical performance of the equipment. An application scheme was proposed. The transformer with the nano-AlN particles in insulating oil was tested in power network to understand its operation status in the conditions of natural load, low load, and over-load. The effects of the nano-additive on the steady-state temperature rise and short-time temperature rise of the transformer were analyzed comparatively. It was found that addition of the nano-particles could strengthen the heat conduction and improve the heat dissipation in transformer, and the decreasing amplitude of steady-state temperature rise in low load condition of the transformer was smaller than that of short-time temperature rise in over-load condition.

参考文献/References:

[1] 缪 金,董 明,吴雪舟,等. 纳米改性变压器油研究进展[J]. 中国电机工程学报,2013,33(9):146-154. MIAO Jin,DONG Ming,WU Xuezhou,et al.Reviews on transformer oil-based nanofluids[J]. Proceedings of the CSEE,2013,33(9):146-154.
[2] 韦 国,刘继午,彭 佳,等. 纳米改性变压器油的击穿及油纸复合绝缘频率响应特性[J]. 高电压技术,2013,39(12):3082-3087. WEI Guo,LIU Jiwu,PENG Jia,et al.Transformer oil breakdown and dielectric frequency response characteristic of oil-paper insulation modified by nanoparticles[J]. High Voltage Engineering,2013,39(12):3082-3087.
[3] 赵智大. 高电压技术[M]. 北京:中国电力出版社,1999:76-77. ZHAO Zhida.Hign voltage engineering[M]. Beijing: China Electric Power Press,1999:76-77.
[4] 油浸式变压器绝缘老化判断导则:DL/T 984—2005[S].2005. Guide for the diagnosis of insulation aging in oil-immersed power transformer:DL/T 984—2005[S].2005.
[5] 周远翔,寇晓适,杨 颖,等. 纳米改性变压器油制备与绝缘特性研究现状[J]. 绝缘材料,2016,49(11):26-35. ZHOU Yuanxiang,KOU Xiaokuo,YANG Ying,et al.Research status on synthesis and insulating properties of nano-modified transformer oil[J]. Insulating Materials,2016,49(11):26-35.
[6] 秦明礼,曲选辉,林健凉,等. 氮化铝陶瓷研究和发展[J]. 稀有金属材料与工程,2002,31(1):8-12. QIN Mingli,QU Xuanhui,LIN Jianliang,et al.Reviews and research on AlN ceramic[J]. Rare Metal Materials and Engineering,2002,31(1):8-12.
[7] CHOI U S.Development and applications of non-newtonianflows[M]. New York:Asme Publication,1995:99-105.
[8] 沈谅平. 纳米改性变压器油的制备及其特性研究[D]. 武汉:华中科技大学,2012. SHEN Liangping.Research on the nano-modified transformer oil’s preparation and characterization[D]. Wuhan:Huazhong University of Science & Technology,2012.
[9] CHOI C,YOO H,OH J.Preparation and heat transfer properties of nanoparticle in transformer oil dispersions as advanced nergy-efficient colants[J]. Current Applied Physics,2008,8(6):710-712.
[10] 周远翔,王云杉,田冀焕,等. 纳米改性变压器油的破坏特性[J]. 高电压技术,2010,36(5):1155-1159. ZHOU Yuanxiang,WANG Yunshan,TIAN Jihuan,et al.Breakdown characteristics in transformer oil modified by nanoparticles[J]. High Voltage Engineering,2010,36(5):1155-1159.
[11] GEORGE J,MARKUS Z,FRANCIS M,et al. Effects of nanoparticle charging on stramer development in transformer oil-based nanofluids[J]. Journal of Applied Physics,2010,107(1):14-31.
[12] KEBLINSKI P,PHILLPOT S R,CHOI S U,et al.Mechanisms of heat flow in suspensions of nano-sized particles (nanofluids)[J]. International Journal of Heat and Mass Transfer,2002,45(4):855-863.
[13] 杜岳凡,吕玉珍,李成榕,等. 半导体纳米粒子改性变压器油的绝缘性能及机制研究[J]. 中国电机工程学报,2012,32(10):177-182. DU Yuefan,LYU Yuzhen,LI Chengrong,et al.Insulating property and mechanism of semiconducting nanoparticles modified transformer oils[J]. Proceedings of the Chinese Society for Electrical Engineering,2012,32(10):177-182.
[14] SEGAL V,HJORTSBERG A,RABINOVICH A,et al.AC(60 Hz)and impulse breakdown strength of a colloidal fluid based on transformer oil and magnetite nano particles[C]//IEEE International Symposium on Electrical Insulation. Arlington,VA,USA:IEEE,1998:619-622.
[15] HWANG J G,ZAHN M,OSULLIVAN F M,et al.Effeects of nanoparticale charging on streamer development in transformer oil-based nanofluids[J]. Journal of Applied Physics,2010,107(1):14310-14317.
[16] 缪 金,董 明,温福新,等. ZnO纳米颗粒改性变压器油介质损耗模型研究[J]. 西安交通大学学报,2014,48(2):50-55. MIAO Jin,DONG Ming,WEN Fuxin,et al.Dielectric loss model of transformer oil-based nanofluids with ZnO nanoparticles[J]. Journal of Xi’an Jiaotong University,2014,48(2):50-55.
[17] DU Yuefan,LU Yuzhen,LI Chengrong,et al. Effect of semiconductive nanoparticles on insulating performances of transformer oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation,2012,19(3):770-776.
[18] 曹晓珑,徐 曼,刘春涛. 纳米添加剂对聚合物击穿性能的影响[J]. 电工技术学报,2006,21(2):8-12. CAO Xiaolong,XU Man,LIU Chuntao.Influence on breakdown property of polymer with nano-addictive[J]. Transactions of China Electrotechnical Society,2006,21(2):8-12.
[19] 寇晓适,任 欢,宋 伟,等. 基于AlN纳米粒子改性的纳米变压器油雷电冲击特性研究[J]. 绝缘材料,2016,49(9):72-76. KOU Xiaokuo,REN Huan,SONG Wei,et al.Study on lightning impulse characteristics of transformer oil modified by AlN nanoparticles[J]. Insulating Materials,2016,49(9):72-76.
[20] 电力变压器试验导则:JB/T 501—2006[S].2006. Test guide for power transformers:JB/T 501—2006[S]. 2006.
[21] 电力变压器第2部分:液浸式变压器的温升:GB 1094.2—2013[S].2013. Power transformers—Part 2:Temperature rise for liquid-immersed transformers:GB 1094.2—2013[S]. 2013.
[22] 运行中变压器油质量:GB/T 7595—2008[S].2008. Quality of transformer oils in service:GB/T 7595—2008 [S].2008.
[23] 变压器油中溶解气体分析和判断导则:DL/T 722—2014 [S].2014. Guide to the analysis and the diagnosis of gases dissolved in transformer oil:DL/T 722—2014[S].2014.

备注/Memo

备注/Memo:
收稿日期:2019-09-30; 修回日期:2019-11-16基金项目:国网河南省电力公司2015科研项目(1512)。Project Supported by State Grid Henan Electric Power Company Technology Project in 2015(1512)。任 欢(1983—),女,工学硕士,高级工程师,现主要从事高电压试验技术、变压器及故障分析方面的研究工作。
更新日期/Last Update: 2020-02-14